HP G2 Service Manual

HP 7 Plus G2 TabletMaintenance and Service GuideIMPORTANT! This document is intended for HP authorized service providers only.

3 Illustrated parts catalogNOTE: HP continually improves and changes product parts. For complete and current information on supported parts for your c

Tablet major componentsItem Component Spare part number(1) Back cover (includes antenna and power/volume button actuator) 790586-001(2) Speaker (inclu

Miscellaneous partsComponent Spare part number5-V / 1-A AC adapter:For use in Asia/Pacific countries and regions 791731-004For use in Europe 791731-00

Spare part number Description790595-001 Rear-facing webcam (2.0-MP, fixed-focus, HD; includes cable)790596-001 Connector board (includes SD Card reade

4 Removal and replacement preliminary requirementsTools requiredYou will need the following tools to complete the removal and replacement procedures:●

Grounding guidelinesElectrostatic discharge damageElectronic components are sensitive to electrostatic discharge (ESD). Circuitry design and structure

Packaging and transporting guidelinesFollow these grounding guidelines when packaging and transporting equipment:●To avoid hand contact, transport pro

Equipment guidelinesGrounding equipment must include either a wrist strap or a foot strap at a grounded workstation.●When seated, wear a wrist strap c

5 Removal and replacement proceduresNOTE: HP continually improves and changes product parts. For complete and current information on supported parts f

4. Remove the back cover (3).NOTE: If the volume button actuator (1) and power button actuator (2) should become displaced during the removal of the b

© Copyright 2014 Hewlett-Packard Development Company, L.P.Bluetooth is a trademark owned by its proprietor and used by Hewlett-Packard Company under l

Reverse this procedure to install the back cover.BatteryDescription Spare part numberBattery (3100-mAh, USB-charging; includes cable and double-sided

5. Remove the battery (5).Reverse this procedure to install the battery.Battery 15

AntennaDescription Spare part numberAntenna (included in the Antenna Kit, spare part number 790600-001. Includes the antenna transceiver, cable, and d

5. Remove the antenna transceiver (5) and cable.6. Remove the antenna board and cables.Reverse this procedure to install the antenna board.SpeakerDesc

1. Unsolder the red and black speaker cables (1) from the system board speaker contact points.NOTE: When installing the speaker, the red speaker cable

Rear-facing webcamDescription Spare part numberRear-facing webcam (2.0-MP, fixed-focus, HD; includes cable) 790595-001Before removing the rear-facing

MicrophoneDescription Spare part numberMicrophone (includes cable) 790597-001Before removing the microphone, follow these steps:1. Turn off the tablet

Reverse this procedure to install the microphone.Connector boardDescription Spare part numberConnector board (includes SD Card reader slot, SIM slot,

5. Remove the Phillips PM1.4×3.6 screw (1) and the Phillips PM1.4×2.2 broad head screw (2) that secure the connector board to the display panel assemb

5. Disconnect the battery cable from the system board (see Battery on page 14).6. Remove the speaker (see Speaker on page 17).Remove the system board:

Safety warning noticeWARNING! To reduce the possibility of heat-related injuries or of overheating the device, do not place the device directly on you

5. Remove the system board (4).Reverse this procedure to install the system board.Front-facing webcamDescription Spare part numberFront-facing webcam

2. Detach the front-facing webcam (2) from the display panel assembly. (The front-facing webcam is attached to the display panel assembly with double-

6 Specifications Metric U.S.Dimensions (portrait orientation)Width 19.3 cm 7.6 inDepth 11.7 cm 4.6 inHeight 0.9 cm 0.4 inWeight (lowest weight config

7 Power cord set requirementsThe wide-range input feature of the tablet permits it to operate from any line voltage from 100 to 120 volts AC, or from

Country/region Accredited agency Applicable note numberSweden CEMKO 1Switzerland SEV 1Taiwan BSMI 4The United Kingdom BSI 1The United States UL 21. Th

8 RecyclingWhen a non-rechargeable or rechargeable battery has reached the end of its useful life, do not dispose of the battery in general household

IndexAAC adapter, spare part numbers7antennaremoval 16spare part number 5, 7Antenna Kit, spare part number5, 7, 16audio, product description 1audio-in

connectors 8plastic parts 8serviceability, product description 1SIM slot 3speakerlocation 3removal 17spare part number 5, 6, 17system boardremoval 22s

iv Safety warning notice

Table of contents1 Product description ...

7 Power cord set requirements ...

1 Product descriptionCategory DescriptionProduct Name HP 7 Plus G2 TabletProcessor Intel® Z2520 1.20-GHz dual core processorPanel 7.0-in [1024×600], A

2 External component identificationItem Component Item Component(1) Rear-facing webcam (6) Power button2 Chapter 2 External component identification

Item Component Item Component(2) Micro USB 2.0 port (7) Volume control buttons (2)(3) Audio-out (headphone)/Audio-in (microphone) jack(8) Micro SD Car